Bell ARH-70 EXP. N445HR

Summary

On 21 February 2007 at about 20:40 local time, a Bell ARH-70 EXP. registered N445HR, operated by BHT, was involved in an accident near Mansfield, Texas, United States. 2 people were on board and nobody was injured. The aircraft was substantially damaged. The NTSB has published a probable cause for this accident; it is quoted in full below.

Date

21 February 2007 at 20:40

Classification

Accident

Location

Mansfield, Texas, United States

Nearest airport

Arlington Municpal Airport (KGKY)

Coordinates

Not recorded

Aircraft

Bell ARH-70 EXP.

Registration

N445HR

Category

Helicopter

Engines

1

Operator

BHT

Operating rule

Part 91: General Aviation

Purpose of flight

Flight Test

Phase of flight

Not recorded

Route

Arlington → Unknown

Aircraft damage

Substantial

Weather

VMC

Light

Day

NTSB number

DFW07CA066

Nobody was injured.

Fuel starvation due to blockage in a fuel system check valve which was the result of the improper assembly of fuel boost pump by company maintenance personnel.

Quoted verbatim from the NTSB record. This site does not paraphrase or interpret it.

Read the full NTSB narrative

The helicopter rolled over during an autorotation following a loss of engine power. The commercial test pilot was performing required test card procedures on the maiden flight of the experimental helicopter. The pilot reported that when he initiated a test flight sequence that called for the helicopter to be configured for slow flight in a shallow descent, the engine low fuel pressure light illuminated followed by an audio alert indicating an engine flame-out. The pilot reported that he immediately entered an autorotation that required a 180-degree turn to the left in order to reach the best available landing area on the fairway of a local golf course. With the helicopter aligned with the intended landing area, the pilot noted that the selected flight path conflicted with a tree on the approach, so the pilot applied collective pitch to slow the rate of descent and clear the tree. As soon as the helicopter cleared the obstacle, the pilot again re-entered a full autorotation. The helicopter touched down in a near level attitude with a slightly faster than normal forward speed. The pilot reported that as the helicopter settled on the golf course fairway, the landing skids began to dig into the soft terrain. The aircraft rocked forward and the toes of the skids dug into the ground, which resulted in the landing gear assembly breaking-off the airframe at all four attachment points and the forward looking infrared mount assembly impacting the ground. The aircraft continued to pivot on the nose and came to rest on its left side, which resulted in structural damage. The investigation revealed that the fuel line to the engine was blocked at the fuel boost pump assembly where the check valve mounts to the fuel switch. Foreign objects were lodged in each of the two check valves, which created a fuel starvation situation and the subsequent engine flame-out.

Quoted verbatim from the NTSB record.