Cessna 336 N3835U

Summary

On 18 June 2022 at about 21:54 local time, a Cessna 336 registered N3835U was involved in an accident near Porterville, California, United States. One person was on board and one died. The aircraft was destroyed. The NTSB has published a probable cause for this accident; it is quoted in full below.

Date

18 June 2022 at 21:54

Classification

Accident

Location

Porterville, California, United States

Coordinates

36.0066, -119.0396

Aircraft

Cessna 336

Registration

N3835U

Category

Airplane

Year built

1964

Engines

2

Operator

Not recorded

Operating rule

Part 91: General Aviation

Purpose of flight

Personal

Phase of flight

Not recorded

Route

Unknown → Shafter

Aircraft damage

Destroyed

Weather

VMC

Light

Day

NTSB number

WPR22FA216

1 person died.

Maintenance personnel’s failure to properly secure the elevator control assembly hardware, which resulted in an in-flight disconnection of the elevator and elevator counterweight and the pilot’s inability to maintain pitch control.

Quoted verbatim from the NTSB record. This site does not paraphrase or interpret it.

Read the full NTSB narrative

Shortly after takeoff, the pilot transmitted over the radio that he had lost “almost all pitch control,” but thought that he would be able to return and land at the departure airport. Automatic Dependent Surveillance Broadcast (ADS-B) data showed that the airplane climbed to about 1,550 ft mean sea level (msl) before entering a descending right 180° turn toward the departure airport. The airplane leveled off about 1,000 ft msl and continued toward the airport. About two minutes later, the airplane entered a descent from 975 ft that continued to ground contact. Witnesses reported that they observed the airplane flying at low altitude when it suddenly descended into the ground in a steep, nose-low, wings-level attitude. Postaccident examination of the wreckage revealed that the bolt, castellated nut, and cotter pin that connected the balance weight to the elevator control assembly were missing. Soot was observed within the area of both connection points, including where the bolt and washer would have been installed, consistent with the hardware not being installed at the time of the accident. It is likely that the bolt separated while in flight, resulting in a loss of elevator pitch control. The missing bolt, nut, washer, and cotter pin were not located. The airplane was painted and returned to service about 28 days before the accident, which included removal and reinstallation of all the flight controls. It could not be determined if the securing hardware (nut and cotter pin) were installed at the time of the reinstallation of the elevator. Toxicology testing of the pilot revealed the presence of ethanol in liver tissue; however, the detected ethanol likely was from postmortem production. Thus, it is unlikely that ethanol contributed to the accident.

Quoted verbatim from the NTSB record.